Karekteristik Lumpur Ipal Kota Jambi Sebagai Bahan Campuran Material Konstruksi
Abstract
Jambi City IPAL is a new construction which is a container for processing Jambi City's domestic waste. The source of the sludge comes from household wastewater in Jambi City. The sludge produced from the Jambi city wastewater treatment process (IPAL) is dark brown in color and the sludge is floc in nature. District is mud whose grains are separated without coagulants, generally this mud contains sand, grit and small gravel fragments. Mud in the form of floc, namely (chemiflocc) is very large in volume, especially in WWTPs. The XRF results of WWTP mud show high levels of SiO2 and Al2O3, namely 61.56% and 26.93% respectively. The elements contained in cement are found in WWTP mud such as SiO2, Al2O3, Fe, CaO, K2O, MgO, and Na2O. If compared, WWTP mud has the same properties as cement. XRD test results show crystal phase conditions show peaks with the highest count value at the position [o2Theta] 26.701OH. The SEM mud results show that the grains are in the form of fragments like irregular lumps with varying grain sizes. This condition shows that dry mud has good binding capacity. Jambi City WWTP waste sludge from XRF results has a mineralogical composition similar to cement, because it contains main oxides such as SiO2, Al2O3, CaO, and Fe. Based on its chemical composition, waste sludge has the potential to be used in the production of construction materials after being subjected to combustion treatment.
Keywords
Full Text:
PDFReferences
Adriansyah, E., Agustina, T. E., & Arita, S. (2019). Leachate Treatment of TPA Talang Gulo, Jambi City by Fenton method and adsorption. Indonesian Journal of Fundamental and Applied Chemistry,4(1), 20–24. https://doi.org/10.24845/ijfac.v4.i1.20
Adriansyah, E., & Syaiful, M. (2024). Korelasi Suhu, pH, TSS Terhadap Pengukuran Parameter Besi Di Sumur Pantau TPA Dengan Minitab 17®. Jurnal Ilmiah Teknik dan Sains, 2(1), 20-24.
Adriansyah, E., Herawati, P., Suzana, A., & Pratama, A. I. (2023). Decreasing pH, COD and TSS of Domestic Liquid Waste Using Photocatalysis TiO2 (Titanium Dioxide). International Journal of Research in Vocational Studies (IJRVOCAS), 3(2), 11–15. https://doi.org/10.53893/ijrvocas.v3i2.201
Adriansyah, E., Herawati, P., Viareco, H., & Sufra, R. (2023). Jurnal Presipitasi Advanced Treatment of Tofu Wastewater using Multilevel Filtration and TiO2 Photocatalysis as Promising Approach for Effective Wastewater Remediation. 20(3), 560–571.
Ab Latif, A., Nazarudin, A., & Muhamad, N. S. (2020). Use of sewage sludge ash as a cement replacement in concrete: A review. Gading Journal of Science and Technology, 3(2), 59-65.
Yiğit, B., Salihoğlu, G., Mardani-Aghabaglou, A., Salihoğlu, N. K., & Özen, S. (2020). Recycling of sewage sludge incineration ashes as construction material. Journal of the Faculty of Engineering and Architecture of Gazi University, 35(3), 1647-1664.
Chang, Z., Long, G., Zhou, J. L., & Ma, C. (2020). Valorization of sewage sludge in the fabrication of construction and building materials: A review. Resources, Conservation and Recycling, 154, 104606.
Grabowski, T. T., Pietrobelli, J. M. T. D. A., & Martins, R. J. E. (2023). Eco-Friendly Cement Mortar with Wastewater Treatment Plant Sludge Upcycling. Clean Technologies, 5(3), 961-972.
Li, D., Zhuge, Y., Liu, Y., Pham, P. N., Zhang, C., Duan, W., & Ma, X. (2021). Reuse of drinking water treatment sludge in mortar as substitutions of both fly ash and sand based on two treatment methods. Construction and Building Materials, 277, 122330.
Mojapelo, K. S., Kupolati, W. K., Ndambuki, J. M., Sadiku, E. R., & Ibrahim, I. D. (2021). Utilization of wastewater sludge for lightweight concrete and the use of wastewater as curing medium. Case Studies in Construction Materials, 15, e00667.
NORUZMAN, T. D. A. H. B., Palil, N., Ahmad, R., & Baharudin, K. S. (2020). Application of waste treatment sludge from water treatment in brick production.
Pham, P. N., Duan, W., Zhuge, Y., Liu, Y., & Tormo, I. E. S. (2021). Properties of mortar incorporating untreated and treated drinking water treatment sludge. Construction and Building Materials, 280, 122558.
Riztu, S., Pradita, N. A., Sufra, R., Adriansyah, E., Suzana, A., Satria, A. W., & Sanjaya, A. (2024). Penurunan Kadar COD Air Limbah Domestik Menggunakan Fly Ash dengan Metode Adsorpsi. Jurnal Ilmiah Universitas Batanghari Jambi, 24(3), 2570-2574.
Sufra, R., Adriansyah, E., & Wati, L. A. (2023). Karbon aktif dari limbah kulit kayu sebagai penyerap logam Mangan (Mn) pada Leachate. Hexatech: Jurnal Ilmiah Teknik, 2(1), 13-16.
Sufra, R., Panjaitan, J. R., Alhanif, M., Mustafa, M., Yusupandi, F., Adriansyah, E., ... & Suzana, A. (2024). Intensifikasi Pengolahan Limbah Cair Laboratorium Melalui Proses Koagulasi dan Adsorpsi Studi Pengolahan Limbah Cair Laboratorium dengan Metode Kombinasi Fisika-Kimia. Jurnal Talenta Sipil, 7(1), 266-275.
Sufra, R., Adriansyah, E., Syaiful, M., & Suzana, A. (2024). Pemanfaatan Adsorben Dari Chip dan Fines Untuk Mengurangi Kontaminan Pada Air Lindi. Jurnal Ilmiah Teknik dan Sains, 2(2), 47-51.
Viareco, H., Adriansyah, E., & Sufra, R. (2023). Potential Sequencing Batch Reactor in Leachate Treatment for Organic and Nitrogen Removal Efficiency. JURNAL KESEHATAN LINGKUNGAN, 15(2), 143–151.https://doi.org/10.20473/jkl.v15i2.2023.143-151
DOI: http://dx.doi.org/10.33087/talentasipil.v8i1.847
Refbacks
- There are currently no refbacks.
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
Jurnal Talenta Sipil, Faculty of Engineering, Batanghari University |
